What is winter truck maintenance tips？

The tips of winter truck maintenance

“Affected by cold weather, trucks will inevitably encounter various problems. Here, I will teach you some common sense of winter truck maintenance and use to help your car survive every icy season.

battery maintenance

When the vehicle is cold started in winter, the load on the starter increases significantly. In order to ensure that the cold start can be successfully completed, is necessary to carry out an inspection and maintenance of the battery, power supply, and grounding cable.

If the battery loses power, remove winter truck maintenance in time and do not charge it; if it loses power frequently, replace the battery after eliminating the cause of the whole vehicle line.

Battery pole cleaning: remove the battery clip, clean the oxide, and re-install it after applying grease.

winter truck maintenance of battery cable and grounding cable: Check the battery grounding cable and the indirect grounding cable between the cylinder block and the frame. If there is obvious rust on the connecting bolt, it needs to be removed, and then reinstalled after removing the rust.

Vehicle power failure: After the vehicle is collected every day, if the vehicle is equipped with a manual power main switch, it needs to be turned off.

pipeline maintenance

Wire harness inspection and: Check whether the wire harness is firmly fixed and whether there is any mechanical interference; check whether the plug of the wire harness is firmly connected, and whether there is water ingress or oil pollution;

Inspection of water pipes, oil pipes and urea pipes: Check whether the pipe joints are firmly fixed, whether the clamps are clamped, and winter truck maintenance whether there is leakage; check whether the pipes are bent, concave, etc.

Air circuit tightness inspection: The air pressure holding time is too short after stopping, or the air pressure drops too fast after stepping on the brake, which winter truck maintenance may be caused by air leakage in the air circuit. Need to check each pipe joint, you can use soapy water to check.

Brake air circuit maintenance

Replacement of drying tank: The recommended replacement cycle of drying tank is 6 months. If you find that winter truck maintenance there is a certain amount of water in each air storage cylinder when you discharge water for the air storage cylinders every day, it means that the dryer has failed, and the drying tank should be replaced in advance.

Dryer exhaust inspection: Check the dryer exhaust port. When obvious oil pollution is found,winter truck maintenance is necessary to check the air compressor and the intake pipe; Some models of air compressors take air from the intake pipe after the supercharger. winter truck maintenance may also be related to the supercharger oil blowing.

Oil level check and replacement

Rear axle and transmission oil inspection: Check the oil level and quality of thewinter truck maintenance main reducer and the wheel end, and replace or supplement if necessary.

Steering assist oil inspection: Check the oil level and quality of the steering oil tank, and replace or supplement if necessary.

Clutch oil inspection: Check the oil level and quality of the clutch oil tank, and replace or supplement if necessary.

Cab turning oil inspection: Check the oil level quality of the turning oil tank, and replace or supplement if necessary.

Chassis butter filling

Fill grease fittings all over the vehicle with grease. it means that the dryer has failed, and the drying tank should be replaced in advance.

When winter truck maintenanceis found that it cannot be injected, winter truck maintenance should be disassembled and repaired.